{"operation":"document","citation":"P-80-043 through P-80-045","title":"NTSB Safety Recommendation Letter P-80-043 through P-80-045","source_type":"guidance","agency":"National Transportation Safety Board","status":"guidance","official":true,"published_on":"1980-06-04","effective_on":"1980-06-04","summary":"Official NTSB transmittal letter for safety recommendations P-80-043 through P-80-045, issued 1980-06-04.","machine_formats":{"json":"https://regulus.evalyn.ai/document/ntsb-transmittal-letter-p80-43-45.json","markdown":"https://regulus.evalyn.ai/document/ntsb-transmittal-letter-p80-43-45.md"},"app_url":"https://regulus.evalyn.ai/document/ntsb-transmittal-letter-p80-43-45","source_url":"https://www.ntsb.gov/safety/safety-recs/recletters/P80_43_45.pdf","body":"Page 1\nWASHINGTON, D.C. ISSUER: June 4 , 1980 Mr. G.H. Lawrence President American Gas Association 1515 Wilson Boulevard Arlington, Virginia 22209 SAFETY RECOMMENDAT ION (5) P-80-43 through -45 Mr. Arie M. Yerrips Executive Director American Public Gas Association 301 Maple Avenue, West Vienna, Virginia 22180 - - - - - - - - _ _ - _ _ - _ _ _ _ _ _ _ _ _ A t 1 1 : l O a.m., e.s.t., on February 21, 1980, an explosion and fire destroyed four stores in a shopping complex and severely damaged an adjoining restaurant in Cordele, Georgia. Of the eight persons who were injured, three died later as a result of their injuries. Property damage was extensive. A gas department construction crew responded promptly to the accident and shut off t h e gas to the affected section of the shopping complex by digging up and closing the tap tee on the gas main. Gas shutoff was completed 45 minutes after the accident. The National Transportation Safety Board's continuing investigation of the accident has revealed that natural gas leaked from a 1-inch steel service line, which had been pulled from a I-inch compression coupling, and migrated under a concrete slab floor and into a jewelry store where it was ignited by an unknown source. On February 18, 1980, a crew from the City of Cordele Gas Department discontinued gas service to a gasoline service station. Since no maps, records, or measurements were available, the crew used a pipe locator to locate the service line and a backhoe to dig for it. While digging for the service line, the backhoe struck and broke it directly behind a row of stores. The crew promptly installed a 1-inch valve and closed it. The crew took no additional action to determine the possibility of further damage. 2944\n\nPage 2\n-2- During the investigation, a survey revealed heavy concentrations end of the shopping complex and parking areas and around a 6-inch gas main the jewelry store. Further investigation revealed that t h e service line ha from a compression coupling located approximately 14 feet upstream of the when the backhoe struck it. Natural gas at 22 psig leaked from the broken co Cordele officials did not report this accident telephonically to t Response Center until 4:30 p.m., on February 21, 1980, over 5 hours after t The Safety Board received its first notification of the accident at 4:35 p.m., 21, 1980, and arrived at the accident site at 4 3 0 pm., February 22, 1980, 29 hours aft the accident. On January 29, 1971, a letter was written by Mr. Joseph C. Cal Director, Office of Pipeline Safety, U.S. Department of Transportation, to each owner operator of gas pipeline facilities, which stated, in part: \"49 CFR 191.5 requires each operator to give direct telephone notice to t Office of Pipeline Safety at the earliest practicable moment followi discovery of certain types of leaks described therein, and identifies t h information to be furnished. In most cases this telephonic report can an should be made within one to two hours after discovery.\" OPSO Advisory Bulletin No. 77-6, June 1977 addressed the fact that some operators had been delinquent in making telephonic notices of reportable leaks to OPSO. The late notification and the consequent late arrival of t h e Safety Board investigator hampered t h e timely onsite witness interrogation and the visual inspection of t h e pipe as it was - unearthed. No gas leak complaints had been received by the gas department befo accident. The gas department's records showed that only 195 gallons of odorant had been put into the gas distribution system between March and November 1979. Records did not exist to corroborate that the odorant level required by 49 CFR 192.625 was maintained. However, the use of only 195 gallons of odorant in this system over a 9-month period would not be consistent with maintenance of an adequate level of odorization as prescribed by regulation. Well odorized gas, leaking'at 22 psig prewure from the open end of a I-inch service line for 3 days before the explosion, should have been easily detected. In addition, if the crew had used a spotting bar and a combustible gas indicator (CGI) upstream of t h e break to determine if additional gas w a s leaking, the accident probably would not have occurred because the compression coupling pullout an as leakage would have been revealed and repaired. The Safety Board is concerned with the unsafe operational practices of the Ci Cordele Gas Department. Therefore, the National Transportation Safety recommends that the American Gas Association and the Americ Notify its member systems of t h e known partic Cordele, Georgia, accident and advise them to re 191.5, Telephonic Reporting of Leaks, Accident Related Failures, to ensure that appropriate instructions have been issued to their employees regarding the reporting requirements. (Class IL, Priority Action) (P-80-43)\n\nPage 3\n-3- Advise its member systems to review and modify as necessary their procedures for maintaining odorization records and files in compliance with CFR 192.625, Qdorization of Gas, and advise its member systems to review and modify as necessary their maintenance and operation procedures to ensure that all leaks resulting from excavator damage have been located and repaired. (Class E, Priority Action) (P-80-44) Advise its member systems to review and modify as necessary their procedures for maintaining necessary maps and records to include all distribution services and record accurate measurements to implement the gas systems operation and maintenance plan. (Class E, Priority Action) (P-80-45) KING, Chairman, DRIVER, Vice Chairman, McADAMS, GOLDMAN, and BURSLEY, Members, concurred in these recommendations.","truncated":false,"body_characters":5686}