# URS Corporation — Hazardous Materials Safety Interpretation - **operation:** document - **citation:** 09-0066 - **title:** URS Corporation — Hazardous Materials Safety Interpretation - **source type:** guidance - **agency:** Pipeline and Hazardous Materials Safety Administration - **status:** guidance - **official:** true - **published on:** 2009-04-30 - **effective on:** Not available - **summary:** 09-0066 response to URS Corporation concerning 173.185. - **machine formats:** - **json:** https://regulus.evalyn.ai/document/phmsa-interpretation-09-0066.json - **markdown:** https://regulus.evalyn.ai/document/phmsa-interpretation-09-0066.md - **app url:** https://regulus.evalyn.ai/document/phmsa-interpretation-09-0066 - **source url:** https://www.phmsa.dot.gov/sites/phmsa.dot.gov/files/legacy/interpretations/Interpretation%20Files/2009/090066.pdf **body:** <<>> U.S. Department of Transportation Pipeline and Hazardous Materials Safety Administration APR 3 0 2009 1200 New Jersey Ave. S.E. Washington, D.C. 20590 Mr. Andrew Romach Regulatory Compliance Manager URS Corporation 1600 Perimeter Park Drive Morrisville, NC 27560 Ref. No.: 09-0066 Dear Mr. Romach: This is in response to your February 20,2009 letter requesting clarification of requirements in the Hazardous Materials Regulations (HMR; 49 CFR Parts 17 1 - 1 80) applicable to design- type testing of lithium ion batteries. The specific requirements you address are contained in Section 38.3 of the United Nations Manual of Tests and Criteria and are implemented through the provisions of fj 1 73.1 85 of the HMR. Specifically, you ask if your configuration constitutes a single lithium ion battery pack or separate lithium ion battery packs. With your letter, you enclose a drawing and describe the configuration of a piece of equipment containing two 9-cell lithium ion battery packs. Each battery pack contains 6.4 grams equivalent lithium content, and each battery pack is equipped with its own safety devices designed to control voltage and current. The battery packs are connected in parallel through a printed circuit board located in a plastic tray. Based on the diagram and information provided, this instrument appears to contain two separate battery packs. You should be aware that effective October 1,2009, the lithium ion batteries described in your letter must be of a type proven to meet the applicable requirements in the UN Manual of Tests and Criteria (see HM-224C, HM-224E, published August 9,2007 (72 FR 44929)). I hope this information is helpful. If you have further questions, please do not hesitate to contact this office. ief, Standards Development Hazardous Materials Standards <<>> February 20,2009 Mr. Ed Mazzullo, Director Office of Hazardous Material Standards Research and Special Programs Administration U.S. Department of Transportation 400 7th Street, SW Washington, DC 20590-0001 FAX: (202) 366-3012 Dear Mr. Mazzullo: I am writing to you to request written clarification about a lithium ion battery configuration. (See schematic attached on following page.) In discussions with Kevin Leary of your staff who reviewed the configuration with the DOT Engineering group, he concluded that the configuration is two separate batteries. I am writing to you for your written confirmation that this lithium ion battery configuration would be considered two separate batteries. As shown in the attached schematic, each independent battery pack contains nine lithium-ion cells wired in a 3S3P configuration. Each pack contains its own "safety board" to prevent over and under voltage and overcurrent. The equivalent lithium content of each pack is 6.4 grams (9 cells x 2.4 Ahr x 0.3). The packs are then connected to a pc board located in a plastic battery tray. Traces on the pc board will connect the two packs in parallel before they are connected to the instrument. Please confirm that the above-described lithium-ion battery configuration as illustrated in the attached schematic would be considered two separate batteries. I appreciate your written clarification of this regulatory question. Sincerely, Andrew N. Romach Regulatory Manager URS Corporation <<>> Page 2 of 2 @ @ 8 A @ A I P C B in Battery Tray I 1 k , , Banana Plugs Instrument Figure 1. Lithium-ion battery Schematic - **truncated:** false - **body characters:** 3445