Sports Health Products — Hazardous Materials Safety Interpretation

Page 1of Transportation U.S. Department 400 Seventh Street, S.W. Washington, D.C. 20590 Pipeline and JUL 21 2005 Administration Hazardous Materiais Safety Mr. Anthony Woods Reference No.: 05-0155 Office Manager Sports Health Products 527 W. Windsor Road Glendale, CA 91204 Dear Mr. Woods: Putty," is not a hazardous material and therefore, not subject to the Hazardous Materials This responds to your letter requesting we confirm that your company's product, "Power Regulations (HMR; 49 CFR Parts 171-180). "Power Putty" is a silicone elastomer used in physical therapy for hand rehabilitation. You enclosed a Material Safety Data Sheet. Under § 173.22, it is the shipper's responsibility to properly classify a hazardous material. This office does not normally perform that function. However, based on the information you submitted, it is the opinion of this office that "Power Putty" does not meet the definition of a hazardous material, and thus, is not subject to the HMR. I hope this satisfies your inquiry. Sincerely, Hattie L. Mitchell Chief, Regulatory Review and Reinvention Office of Hazardous Materials Standards 173.22 050155#

Page 2FROM: SportsHealth SPORTSHEALTH PRODUCTS FAX NO. 8182400112 06-20-05 01:38P P.02 527 W. Windsor Road Glendale, CA 91204 Telephone: (818) 240-7170 Corbin Fax: (818) 240-0112 June 20, 2005 Shipper sensitig Attn: Mr. Edward Mazzullo Director, Office of Hazardous Materials Standards Pipeline & Hazardous Materials Safety Administration 05-0155 U.S. Dot/PHMSA (PHH-10) 400 7'h Street S.W. Washington, D.C. 20590-0001 Mr. Mazzullo, Eileen Edmonson recommended | write this letter to you. I sell Power Putty ™ , a silicone exercise putty that is similar to Silly Putty. Some of my customers are missionaries who travel all around the world with our product. They are concerned airport security screeners will not allow thern to take Power Putty™ on the plane. To prevent this from happening, these customers asked me if I could obtain documentation from you stating our product is safe. I would like to obtain from you a document on official letterhead stating Power Putty™ is a safe product to travel with and is not a hazardous material. Eileen Edmonson asked me to fax this letter along with a copy of our Material Safety Data Sheet to assist you with my request. If you are unable to fulfill my request or if you have any questions, please call me. Thank you for your assistance with this unique situation. Sincerely, Anthon too Anthony Woods Office Manager SportsHealth Products (Please give my thanks to Ms. Edmonson for taking the time out of her busy schedule to answer all of my questions. She was extremely helpful.) The Makers of Power Putty!#

Page 3FROM: Sportshealth .FAX.MO..:-,8182400112 86-28-05 01:25P P.02 Fax #: (202) 366-3012 Pages: 7 (including cover) From: Anthony Woods Corbo Re: Power Putty™ Safety Letter Mr. Mazzullo: Please review the attached letter. If you have any questions, please contact me. Thank you in advance for your assistance. Alliste Anthony Woods SportsHealth Products The Makers of Power Putty!! Thank you for your assistance with this unique situation. Sincerely, Antine to Office Manager Anthony Woods SportsHealth Products (Please give my thanks to Ms. Edmonson for taking the time out of her busy schedule to answer all of my questions. She was extremely helpful.) The Makers of Power Putty!#

Page 4=ROM: SportsHealth sportsheditil Prouucts 06-20-05 01: 26P P.03 MATERIAL SAFETY DATA SHEET Section 1. CHEMICAL PRODUCT/COMPANY IDENTIFICATION Product Name: Silicone Exercise Putty Manufactured and/or Supplied By: 527 W. Windsor Road SportsHealth Products Glendale. CA 91204 Telephone: Generic Description: Fax: (818)240-0112 (818)240-7170 Silicone Elastomer Trade Name/Synonyms: Color: Physical Form: Firm Paste Power Putty Odor: Slight Various Section 2. COMPOSITION/INFORMATION ON INGREDIENTS This material does not contain any hazardous substances at or above OSHA and WHMIS reportable levels. Substances listed in the Subsections HAPS and California Proposition 65 Carcinogens / Reproductive Toxins that are not listed in Section 2 are only present at quantities below 0.1% or they are inextricably bound in the product. Section 3. HAZARDS IDENTIFICATION 3.1 Hazards Classifications Health: 1 HMIS® rating (product as packaged): Fire: 1 Reactivity: 0 PPE: B Hazardous Materials Identification System and HMIS are registered trademarks of the National Paint and Coatings (HMIS codes are based on contact with the product as packaged and any hydrolysis by-products, if present). Association Canadian WHMIS Classification: None 3.2 Emergency Overview and Potential Hazards Physical Hazards: This material is not hazardous under OSHA criteria. This material is not hazardous under WHMIS criteria. No known physical hazards. Acute Health Effects Route of Entry or Possible Contact: Eye Contact: Eyes, Skin, Ingestion Skin Contact: May cause slight eye irritation Inhalation: No acute toxic skin effects are expected high viscosity No acute toxic respiratory tract effects are expected. Inhalation is not expected due lo low vapor pressure or Ingestion: Ingestion is not expected in industrial use. Additional Information on Acute Health Effects: physical nature of this material. exposure to hazardous dusts/particulates is not expected. The health hazard evaluation is based on test results and/or known properties of ingredients. Due to the 3.3 Further Information: None Known Medical Conditions which may be Aggravated by Exposure: Target Organs Affected: No known internal organ eltecis#

Page 5= ROM: SportsHealth Refer to Acule Healt Effecis. isted above. FAX NO.: 8182400112 06-20-05 01:26P P .04 Carcinogens/Reproductive Toxins: normal conditions of use er during any foreseeable emergencies. This material does not contain any reproductive This material does not contain any reportable carcinogenic ingredients. Exposure to carcinogens cannot occur under toxins at or above OSHA er WHMIS reportable levels. See Section 11 for Toxicological Information, if any. Section 4. FIRST AID MEASURES 4.1 General Information: contaminated optic and anoes Get medical attention : ilation or other symptoms occur. Setore seeking medical attention remove treatment. Take a copy of the Material Safety Data Sheet when going for medical 4.2 Material cannot be inhaled under normal conditions. No special measures required. After Inhalation: 4.3 much of the rearing maleral as possible. Wash with soap and water. For skin contact ripe of excess materal with cloth or paper. Use a waterless hand cleaner to remove as After Contact with the Skin: 4.4 If contact with eves, innedistory mold eyelids apart and flush with plenty of water for at least 15 minutes. After Contact with the Eyes: 4.5 After Swallowing: After swallowing: no special treatment is required Section 5. FIRE FIGHTING MEASURES 5.1 Flash Point Flammable Properties: Not Applicable 5.2 Fire and Explosion Hazards: This material dIes e? cresent are unusual fire or explosion hazards. 5.3 Water-spray cou chemica: alcohol resistant foam, carbon dioxide, sand Recommended Extinguishing Media: 5.4 Water je: Unsuitable Extinguishing Media 5.5 Special Exposure Hazards arising from the Substance or Preparation itself, Combustion Products, Resulting Gases: incompletely burn! hydrocarbons Hazardous decomposition products: carbon dioxide. carbon monoxide, formaldehyde, silicon dioxide and 5.6 Fire fighters should wear till pintective clothing including a self-contained breathing apparatus. Cool Fire Fighting Procedures: endangered containers with water. Section 6. ACCIDENTAL RELEASE MEASURES 6.1 No special measures required Precautions: HAZWOPER PPE Level: D 6.2 Containment: Spills of materia wrien could reach surface waters must be reported to the United States Coast Guard Prevent material from entering sewers or surface waters National Rescense renter's eli froe phone number (800)424-8802 6.3 Methods for Cleaning Up: spilled material and niace nan appropriate chemical waste container. Celan any slippery coating that remains using a Scoop up large duentities after dusting surfaces with sand or Fuller's earth to prevent sticking. Sweep or scrape up the detergent/soap stution or snother biodegradable cleaner. Apply sand or other inert granular material to improve#

Page 6FROM: 7.1 SportsHealth Handling: FAX NO. : 8182488112 аменаа 06-20-85 81:26P P. 85 Precautions for Safe Handling: Precautions agains: Fire and Explosion: No special protective measures required No special precautinns agams: ireland explasion required 7.2 Storage None known Conditions for Storage Rooms and Vessels: Not applicable Advice for Storage of Incompatible Materials: Keep container tightly closed Further Information for Storage: • Store in a dry and cool place 8.1 Engineering Controls Section 8: EXPOSURE CONTROLS/PERSONAL PROTECTION Ventilation: Use with adequat 110. Not necessary Local Exhaust: 3.2 None known Associate Substances with Spocific Control Parameters such as Limit Values 8.3 Personal Protection Equipment (PPE) Respiratory protection is net somally required Respiratory Protection: Hand Protection: Eye Protection: Recommendation. i lie id-jer: rubber or vinyl gloves Recommendation Safety glasses with side shields dditional protective clethir: or equipment is not normally required. Provide eye bath and safety shower ther Protective Clothing or Equipment 8.4 Vhen handling do not eat drink smoke or apply cosmetics. Wash thoroughly after handlin eneral Hygiene and Protection Measures 9.1 Section 9. PHYSICAL AND CHEMICAL PROPERTIES Physical Stale/t out: Appearance Color: Odor: NIA 9.2 Flash Point: Safety Parameters Density :HA Section 10. STABILITY AND REACTIVITY :30 10.0 General Information: If stored and handied in accerdance with standard industrial practices no hazardous reactions are known. 10.1 Conditions to Avoia Jone knowr 10.2 Materials to Avoid: None known 10.3 If stored and handled in accordance with standard industrial practices and local regulations where applicable: Hazardous Decomposition Products: above about 150 C: 302 Fy thraugh oxidation none known. Measurements have shown the formation of small amounts of formaldehyde at temperatures 10.4 Further Information: Hazardous palmer ator earen: secur 14.3 Valuation: Air Transport ICAO-T/IATA-DGR Not regulated for transport 15.1 U.S. Federal Regulations Section 15. REGULATORY INFORMATION TSCA Inventory Status and TSCA Information: Chemical Substance inventor: This material on its components are listed on or are in compliance with the requirements of the TSCA This matere•..:". TSCA 12(b) Export Notification: TSCA 12:bi regulated chemicals#

Page 7FROM: Shis product does mat resent 3 SARA 3101312 hazards 8182400112 06-20-05 01:27P P. 86 15.2 The status of this material with regard to some State Listings has not been determined U.S. State Regulations 15.3 14808-60-7 Quartz and or 1333 85-4 Carbon Black California Proposition 65 Carcinogens This material has at: ceor eva unted for the presence of California Proposition 65 Reproductive Toxins. California Proposition 65 Reproductive Toxins 15.4 This product has been classified in accordance with the Hazard criteria of CPR and the MSDS contains all the Canadian Regulations Information required by the CPR None WHMIS Hazard Classes: DSL Status: The Canadian US status of this material has not been determined • • Section 16. OTHER INFORMATION 16.1 Additional Information: This Material Safety Data Sheet (MSDS) meets the requirements of the Federal OSHA Hazard Communication Products Regulations (CPR) and the MSDS contains all of the information required by the CPR. This information Standard (29 CPR 1*10 1203). this product has been classified according to the hazard criteria of the Controlled relates to the specific material designated and may not be valid for such material used in combination with any other date compiled. However, no representation. warranty or guarantee expressed or implied. is made as to its accuracy materials or in any process Such information is the best of our knowledge and belief accurate and reliable as of the reliability or completeness information for mis own particular use. We do not accept liability for any loss or damage that may occur from the use o! il is the user's responsibility to satisfy himself as to the suitability and completeness of such this information its components extending a license ender valie patents. This MSDS provides selected regulatory information on this product, including Meting herem shall be construed as a recommendation for uses which infringe valid patents or as with all applicatie tos. repulatons and laws relating to the product being used Preeneronged to include all regulations. It is the responsibility of the user to know and comply 16.2 Glossary Terms: ACGIH - American Conforence of Governmental ppm - Paris per Million DOT - Department of Transportation Industrial Hygienists STEL - Short Term Exposure Limit SARA - Superfund Amendments and Reauthorization Act hPa - Hectopascals TSCA - Toxic Substances Control Act OSHA - Occupational Safety ang Health Administration mPa*s - Mill Pascal-Seconds TWA - Time Weighted Average PEL - Permissin Exposire:T: WHMIS - Canadlan Workplace Hazardous Materials Identification System ASTM D56 Flash Point Detormination Methods Tagliabue (Tag) closed cup Common Name ASTM D92. DIN S:379. ISO 2592 ASTM 03278 DIN 55680. ISO3379 ASTM 093. OIN 5:758. 180 2713 Cleveland open cup Pensky-Martens closed cur Setaflash or Rapid closed cur DIN 51755 Abel-Pensky closed cup 16.3 Pressure Conversion Table: = 1 Torr: 1 bar = 1000 hPa Viscosity: SportsHealth Products 527 W. Windsor Road • Glendale, CA 91204 • Telephone: (818)240-7170 Fax: (818)240-0112#