Inspectionhistorical
PHMSA vt-2022-gas-program-evaluation
2022 VT NG Program Evaluation - vt-2022-gas-program-evaluation (Vermont; Natural Gas State Program Evaluation)
Current as of source date Government source
RegulusPipeline researchRegulusPipeline researchPHMSA vt-2022-gas-program-evaluation
VT NG Program Evaluation, 2022, page 1Official PDF1200 New Jersey Avenue SE Washington DC 20590 U.S. Department of Transportation Pipeline and Hazardous Materials Safety Administration 2022 Gas State Program Evaluation for VERMONT DEPARTMENT OF PUBLIC SERVICE Document Legend PART: O -- Representative, Dates and Title Information A -- Progress Report and Program Documentation Review B -- Program Inspection Procedures C -- State Qualifications D -- Program Performance E -- Field Inspections F -- Damage prevention and Annual report analysis G -- Interstate Agent/Agreement States DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 1#
VT NG Program Evaluation, 2022, page 22022 Gas State Program Evaluation -- CY 2022 Gas State Agency: Vermont Rating: Agency Status: Date of Visit: 04/25/2023 - 04/27/2023 Agency Representative: Mr. Bill Jordan Director of Engineering PHMSA Representative: Clint Stephens State Liaison Commission Chairman to whom follow up letter is to be sent: Name/Title: Ms. June Tierney, Commissioner Agency: Vermont Public Service Department Address: 112 State Street City/State/Zip: Montpelier, VT 05620-2601 60105(a): Yes 60106(a): No Interstate Agent: No INSTRUCTIONS: Complete this evaluation in accordance with the Evaluator Guidance for conducting state pipeline safety program evaluations. The evaluation should generally reflect state program performance during CY 2022 (not the status of performance at the time of the evaluation). A deficiency in any one part of a multiple-part question should be scored as “Needs Improvement.” Determine the answer to the question then select the appropriate point value. If a state receives less than the maximum points, include a brief explanation in the appropriate notes/comments section. If a question is not applicable to a state, select NA. Please ensure all responses are COMPLETE and ACCURATE, and they OBJECTIVELY reflect the state's program performance for the question being evaluated. Increasing emphasis is being placed on how the state pipeline safety programs conduct and execute their pipeline safety responsibilities (their performance). This evaluation, together with selected factors reported in the state's annual progress report attachments, provide the basis for determining the state's pipeline safety grant allocation. Scoring Summary PARTS Possible Points Points Scored A Progress Report and Program Documentation Review 0 0 B Program Inspection Procedures 15 15 C State Qualifications 10 10 D Program Performance 50 50 E Field Inspections 15 15 F Damage prevention and Annual report analysis 10 10 G Interstate Agent/Agreement States 0 0 TOTALS 100 100 State Rating................................................................................................................................................... 100.0 DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 2#
VT NG Program Evaluation, 2022, page 3PART A - Progress Report and Program Documentation Review Points(MAX) Score 1 Were the following Progress Report Items accurate? (*items not scored on progress Info Only Info Only report) Info Only = No Points a. Stats On Operators Data - Progress Report Attachment 1 b. State Inspection Activity Data - Progress Report Attachment 2 c. List of Operators Data - Progress Report Attachment 3* d. Incidents/Accidents Data - Progress Report Attachment 4* e. Stats of Compliance Actions Data - Progress Report Attachment 5* f. List of Records Kept Data - Progress Report Attachment 6 * g. Staff and TQ Training Data - Progress Report Attachment 7 h. Compliance with Federal Regulations Data - Progress Report Attachment 8 i. Performance and Damage Prevention Question Data - Progress Report Attachment 10* Evaluator Notes: 1a. Review of Attachment 1of Progress Report indicates data is accurate. 1b. Review of Attachment 2of Progress Report indicates data is accurate. 1c. Review of Attachment 3 of Progress Report indicates data is accurate. 1d. Information in Attachment 4 was verified in PDM with no reportable incidents in 2022. 1e. In Attachment 5 of the Progress Report, the 8 should be 42 (Number carried over from all previous CY's) Correction was made by Carrie Winslow. 1f. Review of Attachment 6 of Progress Report indicates data is accurate. 1g. Review of Attachment 7 of Progress Report indicates data is accurate. 1h. Review of Attachment 8 of Progress Report indicates data is accurate. 1i. Review of Attachment 10 of Progress Report indicates information has been updated. Total points scored for this section: 0 Total possible points for this section: 0 DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 3#
VT NG Program Evaluation, 2022, page 4PART B - Program Inspection Procedures Points(MAX) Score 1 Do written procedures address pre-inspection, inspection and post inspection activities 5 5 for each of the following inspection types: Chapter 5.1 Yes = 5 No = 0 Needs Improvement = 1-4 a. Standard Inspections, which include Drug/Alcohol, CRM and Public Awareness Effectiveness Inspections b. TIMP and DIMP Inspections (reviewing largest operator(s) plans annually) c. OQ Inspections d. Damage Prevention Inspections e. On-Site Operator Training f. Construction Inspections (annual efforts) g. LNG Inspections Evaluator Notes: Reviewed the VTPSD operations procedures and found the pre-inspection procedures, pages 7-8; inspection procedures found, pages 8 -12; and post-inspection procedures found pages 12 -15. There were no issues. 2 Do written procedures address inspection priorities of each operator, and if necessary each unit, based on the following elements and time frames established in its procedures? Chapter 5.1 Yes = 4 No = 0 Needs Improvement = 1-3 a. Length of time since last inspection b. Operating history of operator/unit and/or location (includes leakage, incident and compliance activities) c. Type of activity being undertaken by operators (i.e. construction) d. Locations of operator's inspection units being inspected - (HCA's, Geographic area, Population Centers, etc.) e. Process to identify high-risk inspection units that includes all threats - (Excavation Damage, Corrosion, Natural Forces, Outside Forces, Material and Welds, Equipment, Operators and any Other Factors) f. Are inspection units broken down appropriately? 4 4 Evaluator Notes: The written procedures which address inspection priorities is found on pages 8-10. Vermont Gas is inspected on an annual basis, during the winter months. There were no issues. 3 (Compliance Procedures) Does the state have written procedures to identify steps to be 3 3 taken from the discovery to resolution of a probable violation? Chapter 5.1 Yes = 3 No = 0 Needs Improvement = 1-2 a. Procedures to notify an operator (company officer) when a noncompliance is identified b. Procedures to routinely review progress of compliance actions to prevent delays or breakdowns c. Procedures regarding closing outstanding probable violations Evaluator Notes: The procedure for notifying a company officer is found on page 14; follow-up activities for compliance actions is found on page 13; and procedures regarding closing outstanding probable violation is found on page 13. There were no issues. 4 (Incident/Accident Investigations) Does the state have written procedures to address state actions in the event of an incident/accident? Yes = 3 No = 0 Needs Improvement = 1-2 a. Mechanism to receive, record, and respond to operator reports of incidents, including after-hours reports b. If onsite investigation was not made, do procedures require on-call staff to obtain sufficient information to determine the facts to support the decision not to go on-site. 3 3 Evaluator Notes: The procedures to receive, record, and respond to operator reports of incidents; and procedures to not go on site for an DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 4#
VT NG Program Evaluation, 2022, page 5incident investigation are found pages 15 -20. There were no issues. TOTAL ‐ 5 General Comments: Info Only = No Points Evaluator Notes: There were no issues identified in Part B of the program evaluation. Info Only Info Only Total points scored for this section: 15 Total possible points for this section: 15 DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 5#
VT NG Program Evaluation, 2022, page 6PART C - State Qualifications Points(MAX) Score 1 Has each inspector and program manager fulfilled training requirements? (See Guidelines Appendix C for requirements) Chapter 4.3 Yes = 5 No = 0 Needs Improvement = 1-4 a. Completion of Required OQ Training before conducting inspection as lead b. Completion of Required DIMP/IMP Training before conducting inspection as lead c. Completion of Required LNG Training before conducting inspection as lead d. Root Cause Training by at least one inspector/program manager e. Note any outside training completed f. Verify inspector has obtained minimum qualifications to lead any applicable standard inspection as the lead inspector (Reference State Guidelines Section 4.3.1) 5 5 Evaluator Notes: issues. Each inspector and program manager has fulfilled their training requirements in the VT pipeline safety office. There were no 2 Did state records and discussions with state pipeline safety program manager indicate 5 5 adequate knowledge of PHMSA program and regulations? Yes = 5 No = 0 Needs Improvement = 1-4 Evaluator Notes: The program manager displayed adequate knowledge of PHMSA program and regulations during program evaluation discussions. 3 General Comments: Info Only = No Points Evaluator Notes: There were no issues identified in Part C of the program evaluation. Info Only Info Only Total points scored for this section: 10 Total possible points for this section: 10 DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 6#
VT NG Program Evaluation, 2022, page 7PART D - Program Performance Points(MAX) Score 1 Did state inspect all types of operators and inspection units in accordance with time 5 5 intervals established in written procedures? Chapter 5.1 Yes = 5 No = 0 Needs Improvement = 1-4 a. Standard (General Code Compliance) b. Public Awareness Effectiveness Reviews c. Drug and Alcohol d. Control Room Management e. Part 193 LNG Inspections f. Construction (did state achieve 20% of total inspection person-days?) g. OQ (see Question 3 for additional requirements) h. IMP/DIMP (see Question 4 for additional requirements) Evaluator Notes: Standard - Vermont Gas Systems, Inc. (Distr) (4/4/2022 & 8/22/2018); Blue Flame Gas Company, Inc. (4/13/22 ? Records & 7/9/21); Bournes Propane (5/5/22 & 7/31/19); Dead River Company (1/27/22 & 3/11/21); Fyles Brothers, Inc. (7/27/22 & 3/10/20); Haskins Gas Service (6/17/21 & 10/9/19); Highland Fuel Delivery (4/27/22, 8/2/22, 2/3/22 & 3/4/20, 1/11/19, 11/19/18); HOP Energy, LLC (3/9/22 & 6/5/18); Jack F. Corse Co. ( 8/17/21 & 2/5/20); Jackman Fuels, Inc. (9/2/20 & 4/6/18); NGL Partners of Oklahoma (7/20/22 & 9/30/21); Proctor Gas (7/20/21 & 7/21/16); Surburban Propane Co. H (5/13/22, 6/3/22, & 11/5/18, 5/16/19); UGI Corp. dba Amerigas (3/10/22 & 8/12/21); Vermont Gas Systems, Inc. (Trans) (10/31/22 & 8/17/18) PAP - Vermont Gas Systems, Inc. (Distr-Trans) (9/23/21); Blue Flame Gas Company, Inc. (9/4/19); Bournes Propane (5/6/19); Dead River Company (9/4/19); Fyles Brothers, Inc. (5/9/19); Haskins Gas Service (7/2/19); Highland Fuel Delivery (9/4/13); HOP Energy, LLC (5/28/19); Jack F. Corse Co. (7/29/19); Jackman Fuels, Inc. (9/4/19); NGL Partners of Oklahoma (5/9/19); Proctor Gas (9/4/19); Surburban Propane Co. H (9/4/19); UGI Corp. dba Amerigas (9/4/19) D&A - Vermont Gas Systems, Inc. (Distr-Trans) (4/1/21) CRM - Vermont Gas Systems, Inc. (Trans) (1/25/22 & 3/15/18)) OQ - Vermont Gas Systems, Inc. (Distr -Trans) (2/11/20); Blue Flame Gas Company, Inc. (2/12/20); Bournes Propane (8/21/20); Dead River Company (10/7/20); Fyles Brothers, Inc. (9/3/20); Haskins Gas Service (6/25/20); Highland Fuel Delivery (10/15/20); HOP Energy, LLC (6/5/18 Co. ); Jack F. Corse (3/29/22 & 8/8/17); NGL Partners of Oklahoma (8/11/20); Proctor Gas (5/7/20); Surburban Propane Co. H (9/4/20); UGI Corp. dba Amerigas (4/22/20) IMP/DIMP - Vermont Gas Systems, Inc. (Distr) (11/17/21); Vermont Gas Systems, Inc. (Trans) (11/17/19); Blue Flame Gas Company, Inc. (4/6/22 & 2/12/20); Bournes Propane (9/8/21); Dead River Company (10/21/20); Fyles Brothers, Inc. (2/10/21); (2/10/21); Haskins Gas Service (10/30/21); Highland Fuel Delivery (5/19/21); HOP Energy, LLC (6/21/22 & 4/18/18); Jack F. Corse Co (12/22/20); Jackman Fuels, Inc. (12/23/20); NGL Partners of Oklahoma (8/25/21); Proctor Gas (7/20/21); Surburban Propane Co. H (2/16/22 & 5/10/18); UGI Corp. dba Amerigas (4/26/21); and Construction - Vermont Gas Systems, Inc. (Distr) (2/2/22,2/23/22, 4/15/22, 5/12/22, 5/17/22, 6/24/22, 6/30/22). There were no issues. 2 Did inspection form(s) cover all applicable code requirements addressed on Federal Inspection form(s)? Did State complete all applicable portions of inspection forms? Chapter 5.1. Do inspection records indicate that adequate reviews of procedures, records and field activities, including notes and the appropriate level of inspection person-days for each inspection, were performed? Yes = 10 No = 0 Needs Improvement = 1-9 a. Standard (General Code Compliance) b. Public Awareness Effectiveness Reviews c. Drug and Alcohol d. Control Room Management e. Part 193 LNG Inspections f. Construction g. OQ (see Question 3 for additional requirements) h. IMP/DIMP (see Question 4 for additional requirements) 10 10 Evaluator Notes: Reviewed inspection reports: Standard - Vermont Gas Systems, Inc. (Distr) (4/4/2022) inspection form in IA had 12 questions that were still pending; Blue Flame Gas Company, Inc. (4/13/22) IA form should have some questions identified as DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 7#
VT NG Program Evaluation, 2022, page 8N/A, but should have been N/C; Bournes Propane (5/5/22) ? still open; Dead River Company (1/27/22); Fyles Brothers, Inc. (7/27/22) ? still open ? deadline May 17, 2023; Highland Fuel Delivery (8/2/22); HOP Energy, LLC (3/9/22); NGL Partners of Oklahoma (7/20/22); Surburban Propane Co. H (6/3/22); UGI Corp. dba Amerigas (3/10/22); Vermont Gas Systems, Inc. (Trans) (10/31/22) ? open inspection; CRM - Vermont Gas Systems, Inc. (Trans) (1/25/22) OQ - Jack F. Corse (3/29/22); and DIMP - HOP Energy, LLC (6/21/22) and Surburban Propane Co. H (2/16/22). There were no issues. 3 Is state verifying monitoring (Protocol 9/Form15) of operators OQ programs? This 2 2 should include verification of any plan updates and that persons performing covered tasks (including contractors) are properly qualified and requalified at intervals established in the operator's plan. 49 CFR 192 Part N Yes = 2 No = 0 Needs Improvement = 1 Evaluator Notes: Reviewed inspection report: Jack F. Corse (3/29/22). Also, OQ Protocol 9 ? Blue Flame (5/6/22) and Keyser Energy (5/11/22). No issues. 4 Is state verifying operator's integrity management Programs (IMP and DIMP)? This should include a review of plans, along with monitoring progress. In addition, the review should take in to account program review and updates of operator's plan(s). 49 CFR 192 Subparts O and P Yes = 2 No = 0 Needs Improvement = 1 a. Are the implementation plans of the state's large/largest operators(s) being reviewed annually to ensure they are completing full cycle of the IMP process? b. Are states verifying with operators any plastic pipe and components that have shown a record of defects/leaks and mitigating those through DIMP plan? c. Are the states verifying operators are including low pressure distribution systems in their threat analysis? 2 2 Evaluator Notes: Reviewed DIMP inspection reports: HOP Energy, LLC (6/21/22) and Surburban Propane Co. H (2/16/22). No issues. 5 Did the state review the following (these items are NTSB recommendations to PHMSA that have been deemed acceptable response based on PHMSA reviewing these items during the evaluation process): Chapter 5.1 Yes = 2 No = 0 Needs Improvement = 1 a. Operator procedures for determining if exposed cast iron pipe was examined for evidence of graphitization and if necessary remedial action was taken; b. Operator procedures for surveillance of cast iron pipelines, including appropriate action resulting from tracking circumferential cracking failures, study of leakage history, or other unusual operating maintenance condition? (Note: See GPTC Appendix G-18 for guidance); c. Operator emergency response procedures for leaks caused by excavation damage near buildings and determine whether the procedures adequately address the possibility of multiple leaks and underground migration of gas into nearby buildings Refer to 4/12/01 letter from PHMSA in response to NTSB recommendation P-00-20 and P-00-21; d. Operator records of previous accidents and failures including reported third- party damage and leak response to ensure appropriate operator response as required by 192.617; e. Directional drilling/boring procedures of each pipeline operator or its contractor to determine if they include actions to protect their facilities from the dangers posed by drilling and other trench less technologies; f. Operator procedures for considering low pressure distribution systems in threat analysis? g. Operator compliance with state and federal regulations for regulators located inside buildings? Evaluator Notes: a. Vermont has no cast iron pipe in the state. DUNS: 809376791 2022 Gas State Program Evaluation 2 2 Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 8#
VT NG Program Evaluation, 2022, page 9b. Vermont has no cast iron pipe in the state. c. This item is discussed with the operator during standard inspections. d. VTDPS continually discusses and reviews all underground damage reports with Dig Safe Inc. in the state. e. VTDPS discusses this item during their Standard Distribution inspections. f. Vermont has no low-pressure distribution systems. g. VTDPS discuss this issue with Vermont Gas during DIMP inspections. VGS has 115 inside regulator sets which are all vented to the outside. 6 Did the State verify Operators took appropriate action regarding advisory bulletins issued since the last evaluation? (Advisory Bulletins Current Year) Yes = 1 No = 0 Needs Improvement = .5 Evaluator Notes: When a new ADB is issued, they are emailed to the operator. 1 1 7 (Compliance Activities) Did the state follow compliance procedures (from discovery to resolution) and adequately document all probable violations, including what resolution or further course of action is needed to gain compliance? Chapter 5.1 Yes = 10 No = 0 Needs Improvement = 1-9 a. Were compliance actions sent to company officer or manager/board member if municipal/government system? b. Were probable violations documented properly? c. Resolve probable violations d. Routinely review progress of probable violations e. Did state issue compliance actions for all probable violations discovered? f. Can state demonstrate fining authority for pipeline safety violations? g. Does Program Manager review, approve and monitor all compliance actions? (note: Program Manager or Senior Official should sign any NOPV or related enforcement action) h. Did state compliance actions give reasonable due process to all parties? Including "show cause" hearing, if necessary. i. Within 30 days, conduct a post-inspection briefing with the owner or operator outlining any concerns j. Within 90 days, to the extent practicable, provide the owner or operator with written preliminary findings of the inspection. (Incident investigations do not need to meet 30/90-day requirement) 10 10 Evaluator Notes: VTDPS had sent compliance letters to company officers/managers. Probable violations were documented properly. Bournes Propane (5/5/22) ? still open ? operator has been given a July 2023 deadline and Fyles Brothers, Inc. (7/27/22) ? still open ? deadline May 17, 2023. There were no issues. 8 (Incident Investigations) Were all federally reportable incidents investigated, thoroughly documented, with conclusions and recommendations? Yes = 10 No = 0 Needs Improvement = 1-9 a. Does state have adequate mechanism to receive and respond to operator reports of incidents, including after-hours reports? b. Did state keep adequate records of Incident/Accident notifications received? c. If onsite investigation was not made, did the state obtain sufficient information from the operator and/or by means to determine the facts to support the decision not to go on site? d. Were onsite observations documented? e. Were contributing factors documented? f. Were recommendations to prevent recurrences, where appropriate, documented? 10 10 DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 9#
VT NG Program Evaluation, 2022, page 10g. Did state initiate compliance action for any violations found during any incident/accident investigation? h. Did state assist Region Office or Accident Investigation Division (AID) by taking appropriate follow-up actions related to the operator incident reports to ensure accuracy and final report has been received by PHMSA? i. Does state share any lessons learned from incidents/accidents? Evaluator Notes: There were no reportable incidents in CY2022. 9 Did state respond to Chairman's letter on previous evaluation within 60 days and correct or address any noted deficiencies? (If necessary) Chapter 8.1 Yes = 1 No = 0 Needs Improvement = .5 Evaluator Notes: Chair letter sent 11/3/22, response received on 12/21/22. No issue. 1 1 10 Did State conduct or participate in pipeline safety training session or seminar in Past 3 Years? Chapter 8.5 Info Only = No Points Evaluator Notes: Info Only Info Only VTDPS participated in the NEPSR (New England Pipeline Safety Representatives) seminar on March 30, 2022. 11 Has state confirmed transmission operators have submitted information into NPMS database along with changes made after original submission? Info Only = No Points Evaluator Notes: Yes. Vermont Gas had submitted information to NPMS in March 2022. Info Only Info Only 12 Does the state have a mechanism for communicating with stakeholders - other than state 1 1 pipeline safety seminar? (This should include making enforcement cases available to public). Yes = 1 No = 0 Needs Improvement = .5 Evaluator Notes: VTPSD participates in the annual underground awareness seminars/training (10/26/22) and pipeline safety information is on the state website. 13 Did state execute appropriate follow-up actions to Safety Related Condition (SRC) Reports? Chapter 6.7 Yes = 1 No = 0 Needs Improvement = .5 Evaluator Notes: There were no open SRC reports in PDM for VTDPS. 1 1 14 Was the State responsive to: Yes = 1 No = 0 Needs Improvement = .5 a. Surveys or information requests from NAPSR or PHMSA; and b. PHMSA Work Management system tasks? Evaluator Notes: VTDPS responded to NAPSR and/or PHMSA requests for information. VTDPS had no tasks in WMS. 1 1 15 If the State has issued any waivers/special permits for any operator, has the state verified conditions of those waivers/special permits are being met? This should include having the operator amend procedures where appropriate. Yes = 1 No = 0 Needs Improvement = .5 Evaluator Notes: 1 1 VTDPS has no waivers/special permits. DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 10#
VT NG Program Evaluation, 2022, page 1116 Were pipeline program files well-organized and accessible? Info Only = No Points Evaluator Notes: Yes. Files were well-organized and accessible. Info Only Info Only 17 Discussion with State on accuracy of inspection day information submitted into State Inspection Day Calculation Tool (SICT). Has the state updated SICT data? Yes = 3 No = 0 Needs Improvement = 1-2 Evaluator Notes: Discussed with State on accuracy of inspection day information submitted into SICT. There were no issues. 3 3 18 Discussion on State Program Performance Metrics found on Stakeholder Communication site.\ http://primis.phmsa.dot.gov/comm/states.htm?nocache=4805 Info Only = No Points Evaluator Notes: Discussed performance metrics with VTDPS. There were no issues with negative trends. Info Only Info Only 19 Did the state encourage and promote operator implementation of Pipeline Safety Management Systems (PSMS), or API RP 1173? This holistic approach to improving pipeline safety includes the identification, prevention and remediation of safety hazards. Info Only = No Points a. https://pipelinesms.org/ b. Reference AGA recommendation to members May 20, 2019 Evaluator Notes: Vermont Gas has implemented PSMS within their organization. Info Only Info Only 20 General Comments: Info Only = No Points Evaluator Notes: There were no issues in Part D of the program evaluation. Info Only Info Only Total points scored for this section: 50 Total possible points for this section: 50 DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 11#
VT NG Program Evaluation, 2022, page 12PART E - Field Inspections Points(MAX) Score 1 Operator, Inspector, Location, Date and PHMSA Representative (enter specifics into the Info Only Info Only comments box below) Info Only = No Points a. What type of inspection(s) did the state inspector conduct during the field portion of the state evaluation? (i.e. Standard, Construction, IMP, etc) b. When was the unit inspected last? c. Was pipeline operator or representative present during inspection? d. Effort should be made to observe newest state inspector with least experience Evaluator Notes: Operator: Fyles Brothers, Inc. Inspector(s): Matt Hecklinger Location(s): 6 South St., Bristol, VT (Henderson Block); 47 Donovan Ln., Vergennes, VT (Rivers Edge Cottages); and 5 Park St., Middlebury, VT (Star Mill) Date(s): April 26, 2023 PHMSA Rep.: Clint Stephens Comments: VTPSD performed a standard field inspection on a propane operator. The pipeline operator was present during the inspection. 2 Did the inspector use an appropriate inspection form/checklist and was the form/checklist used as a guide for the inspection? (New regulations shall be incorporated) Yes = 2 No = 0 Needs Improvement = 1 Evaluator Notes: Yes. The inspector was using Standard Gas Distribution inspection form. 2 2 3 Did the inspector adequately review the following during the inspection 10 10 Yes = 10 No = 0 Needs Improvement = 1-9 a. Procedures (were the inspector's questions of the operator adequate to determine compliance?) b. Records (did the inspector adequately review trends and ask in-depth questions?) c. Field Activities/Facilities (did inspector ensure that procedures were being followed, including ensuring that properly calibrated equipment was used and OQ's were acceptable?) d. Other (please comment) e. Was the inspection of adequate length to properly perform the inspection? Evaluator Notes: Yes. The inspector adequately reviewed propane facilities in the field during the inspection. 4 From your observation did the inspector have adequate knowledge of the pipeline safety program and regulations? (Evaluator will document reasons if unacceptable) Yes = 2 No = 0 Needs Improvement = 1 Evaluator Notes: From my observation, the inspector had adequate knowledge of the pipeline safety program and regulations. 2 2 5 Did the inspector conduct an exit interview, including identifying probable violations? (If inspection is not totally completed the interview should be based on areas covered during time of field evaluation) Yes = 1 No = 0 Needs Improvement = .5 Evaluator Notes: The inspector conducted an exit brief-out at each site location after each field inspection. 1 1 6 Was inspection performed in a safe, positive, and constructive manner ? DUNS: 809376791 2022 Gas State Program Evaluation Info Only Info Only Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 12#
VT NG Program Evaluation, 2022, page 13Info Only = No Points a. No unsafe acts should be performed during inspection by the state inspector b. What did the inspector observe in the field? (Narrative description of field observations and how inspector performed) c. Best Practices to Share with Other States - (Field - could be from operator visited or state inspector practices) d. Other Evaluator Notes: The inspection was performed in a safe, positive, and constructive manner. The inspector observed regulatory safety conditions of the propane facilities, such as marker signs, atmospheric corrosion, over pressure protection, tank/meter supports, tracer wire, etc. 7 General Comments: Info Only = No Points Evaluator Notes: There were no issues identified in Part E of the program evaluation. Info Only Info Only Total points scored for this section: 15 Total possible points for this section: 15 DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 13#
VT NG Program Evaluation, 2022, page 14PART F - Damage prevention and Annual report analysis Points(MAX) Score 1 Has the state reviewed Operator Annual reports, along with Incident/Accident reports, for accuracy and analyzed data for trends and operator issues. Yes = 2 No = 0 Needs Improvement = 1 2 2 Evaluator Notes: accuracy and trends. VTDPS reviewed data analysis from the 2022 operator annual report (Vermont Gas System). This data was analyzed for 2 Has the state verified that the operators analyze excavation damages for the purpose of 2 2 determining root causes and minimizing the possibility of a recurrence? (192.617) Has the state verified that the operators have appropriately identified excavators who have repeatedly violated one-call laws and damaged their facilities. Have the operators taken steps to mitigate that risks? (192.1007) Yes = 2 No = 0 Needs Improvement = 1 Evaluator Notes: The state has verified that VGS has analyzed excavation damages for the purpose of determining root causes and minimizing the possibility of recurrence. VGS has identified contractors as the party that has the most excavation damages. No issues. 3 Has the state reviewed the operator's annual report pertaining to Part D - Excavation 4 4 Damage? Yes = 4 No = 0 Needs Improvement = 1-3 a. Is the information complete and accurate with root cause numbers? b. Has the state evaluated the causes for the damages listed under "One-Call Notification Practices Not Sufficient" (Part D.1.a.)? c. Has the state evaluated the causes for the damages listed under "Locating Practices Not Sufficient" (Part D.1.b)? For each operator, does the state review the following? d. Is the operator or its locating contractor(s) qualified and following written procedures for locating and marking facilities? e. Is the operator appropriately requalifying locators to address performance deficiencies? f. What is the number of damages resulting from mismarks? g. What is the number of damages resulting from not locating within time requirements (no-shows)? h. Is the operator appropriately addressing discovered mapping errors resulting in excavation damages? i. Are mapping corrections timely and according to written procedures? j. Has the state evaluated the causes for the damages listed under "Excavation Practices Not Sufficient" (Part D.1.c.)? Evaluator Notes: Reviewed the data with VTDPS pertaining to Part D ? Excavation Damage in annual report for Vermont Gas from 2021 ? 2023. The information is complete with root cause numbers. There were no issues. 4 Has the agency or another organization within the state collected data and evaluated trends on the number of pipeline damages per 1,000 locate requests? Yes = 2 No = 0 Needs Improvement = 1 a. What stakeholder group is causing the highest number of damages to the pipelines? Operator, contractor, locating company or public. b. Has the state verified the operator is appropriately focusing damage prevention education and training to stakeholders causing the most damages? c. Has the state evaluated which of the following best describes the reason for the excavation damages; i.e., operator or contractor not following written procedures, failure to maintain marks, failure to support exposed facilities, failure to use hand tools were required, failure to test-hole (pot hole), improper backfilling practices, failure to maintain clearance or insufficient excavation practices. d. Has the state verified the operator is appropriately focusing damage prevention education and training to address the causes of excavation damages? Evaluator Notes: DUNS: 809376791 2022 Gas State Program Evaluation 2 2 Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 14#
VT NG Program Evaluation, 2022, page 15Yes. VTDPS has collected data and evaluated trends on the number of pipeline damages per 1,000 locates. It was determined that the excavator is causing the highest number of damages. VGS has presented at the MUST (Managing Underground Safety Training) meetings on excavation training. Information is posted on the MUST website on the precautions to take before and during excavation. 5 General Comments: Info Only = No Points Evaluator Notes: There were no issues identified in Part F of the program evaluation. Info Only Info Only Total points scored for this section: 10 Total possible points for this section: 10 DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 15#
VT NG Program Evaluation, 2022, page 16PART G - Interstate Agent/Agreement States Points(MAX) Score 1 Were all inspections of interstate pipelines conducted using the Inspection Assistant program for documenting inspections? Info Only = No Points Evaluator Notes: VT DPS is not an interstate agent and does not have a 60106 agreement with PHMSA. Info Only Info Only 2 If inspections were conducted independent of a PHMSA team inspection was notice of all Info Only Info Only identified probable violations provided to PHMSA within 60 days? Info Only = No Points Evaluator Notes: VT DPS is not an interstate agent and does not have a 60106 agreement with PHMSA. 3 If inspections were conducted independent of a PHMSA team inspection was PHMSA immediately notified of conditions which may pose an immediate safety hazard to the public or environment? Info Only = No Points Evaluator Notes: VT DPS is not an interstate agent and does not have a 60106 agreement with PHMSA. Info Only Info Only 4 If inspections were conducted independent of a PHMSA team inspection did the state coordinate with PHMSA if inspections not were not included in the PHMSA Inspection Work Plan? Info Only = No Points Evaluator Notes: VT DPS is not an interstate agent and does not have a 60106 agreement with PHMSA. Info Only Info Only 5 Did the state take direction from and cooperate with PHMSA for all incident investigations conducted on interstate pipelines? Info Only = No Points Evaluator Notes: VT DPS is not an interstate agent and does not have a 60106 agreement with PHMSA. Info Only Info Only 6 General Comments: Info Only = No Points Evaluator Notes: VT DPS is not an interstate agent and does not have a 60106 agreement with PHMSA. Info Only Info Only Total points scored for this section: 0 Total possible points for this section: 0 DUNS: 809376791 2022 Gas State Program Evaluation Vermont VERMONT DEPARTMENT OF PUBLIC SERVICE, Page: 16#
This material provides agency context. It does not replace binding regulatory text, and its legal effect depends on the underlying authority and facts.